Here is a portable solar generating system I built last year. It was built to power an ARB 12v refrigerator and as a power station for base camping trips. In a nut shell it's a Goal Zero Yeti 1250 for less than a third of the cost.
Here is the breakdown. I purchased these three dustproof containers at Home Depot ($98 OTD special) I only used the bottom wheeled box which by itself was $60.
Next up was selecting the battery. I wanted something sealed so I went with a 70ah AMG battery from Auto Zone. I considered Optima but from my research the new ones lack quality and were WAY more expensive. The charge controller is a Morningstar 10amp model from Amazon ($56).
I went with Blue Sea for the fuse panel, master switch, 12v outlets and the USB outlet. Amazon had them but they were about 10% cheaper from a marine shop on EBay.
Here is the almost completed interior. I still need to cut some stiff foam to hold the battery in place.
The RENOGY 100 Watt 12v solar panel was purchased from Amazon for $150. I also bought with it a 25 foot cord and cut it in half so I could have a positive and negative 12" section with the correct connectors for the panel. On the box side I went with an easier to connect/disconnect plug type.
All the wiring is 10 gauge except for the wiring to the USB. Goal Zero wanted about $1600 for their unit plus a few hundred for the solar panel. I'm in it for less than $500 and am very happy with the final results. The rolling box weighs about 50 pounds and the panel weighs just a few pounds. I still need to make some folding legs for the panel and sew up a neoprene sleeve to store it in.
The experiment starts this morning and this should be a good test. Today's forecasted high...... 113F (45C) with an evening low of 85F (29C)
This turns out to be a great week to test things out. Record heat (114F) yesterday and hotter (115F) today. Here is the data thus far.
Battery started the test at 13.0v at 10:00a yesterday and the fridge set and pre-cooled to 32F.
07:00a this morning the battery was at 12.4v and the evening low was 82F
08:30a I lower the t-stat to 30F.
115F on the patio, the fridge is 27F degrees and the battery is 100% topped off. I'm calling this a successful project.