donb
Well-known member
Selling the drivetrain out of my 110 to make room for the R2.8 to go in.
I bought this Disco 200tdi off eBay in the summer of 2018.
The install thread is here: https://nas-row.com/index.php?threads/discovery-200tdi-into-defender.2343/
Compression test before I installed had 400-450 psi in all cylinders.
These parts were new in 2018:
Turbo Technics VVT for 300tdi
2.5" stainless downpipe with 2 v-band clamps
Glencoyne Engine Mounts
machined flywheel
clutch - HD - PLL779 - Rovers North
Flywheel gasket - PLX233 - Rovers North
oil cooler lines ERR1913 and ERR1912 - Rovers North
RN 200tdi Radiator - PLD496 - Rovers North
Glow plugs - PLH391 - Rovers North
Land Rover Timing Belt - Rovers North
Timing Belt Tensioner - PLL539 - Rovers North
Timing Belt Idler Pulley - PLL535 - Rovers North
Glow Plug Wire - AMR2425 - Rovers North
Water Pump - PLN036 - Rovers North
Drive Belt - ETC7469 - Rovers North
Thermostat Housing - ETC5967 - Rovers North
EGT probe
powercoated intake
powdercoated valve cover
ceramic coated exhaust
alternator
vibration damper PLQ425 - Rovers North
bolt crankshaft pulley ERR605 - Rovers North
300tdi dipstick ERR3809
Glowplug Relay PLL637
ERR2532 - Rear Oil Seal - TURNER ENGINEERING PARTS
ERR913 - T Seal - TURNER ENGINEERING PARTS
ERR1440 - Flywheel to Block - TURNER ENGINEERING PARTS
BTR982 - Heater Hose - TURNER ENGINEERING PARTS
Installed in 2019:
thicker eBay intercooler
Donaldson M002118 air filter clamps
Donaldson 546743 air filter
Stanadyne FM100 Fuel Filter setup
Revotec Electric Fan kit - Jan 2019
Valve cover gasket - March 2019
-6 AN Lines and fittings to IP
Approximately - 3,000 miles since 200tdi install
R380 Shorty
Serial: 55A60623008J
Purchased Sept 2014 from David Dearborn/Urban Land Cruisers
But didn't start using until 2016 after I finished the build of the 110. It was first behind an OM617
Approximately 5,000 miles on gearbox
Redlne fluid
$4,000
I bought this Disco 200tdi off eBay in the summer of 2018.
The install thread is here: https://nas-row.com/index.php?threads/discovery-200tdi-into-defender.2343/
Compression test before I installed had 400-450 psi in all cylinders.
These parts were new in 2018:
Turbo Technics VVT for 300tdi
2.5" stainless downpipe with 2 v-band clamps
Glencoyne Engine Mounts
machined flywheel
clutch - HD - PLL779 - Rovers North
Flywheel gasket - PLX233 - Rovers North
oil cooler lines ERR1913 and ERR1912 - Rovers North
RN 200tdi Radiator - PLD496 - Rovers North
Glow plugs - PLH391 - Rovers North
Land Rover Timing Belt - Rovers North
Timing Belt Tensioner - PLL539 - Rovers North
Timing Belt Idler Pulley - PLL535 - Rovers North
Glow Plug Wire - AMR2425 - Rovers North
Water Pump - PLN036 - Rovers North
Drive Belt - ETC7469 - Rovers North
Thermostat Housing - ETC5967 - Rovers North
EGT probe
powercoated intake
powdercoated valve cover
ceramic coated exhaust
alternator
vibration damper PLQ425 - Rovers North
bolt crankshaft pulley ERR605 - Rovers North
300tdi dipstick ERR3809
Glowplug Relay PLL637
ERR2532 - Rear Oil Seal - TURNER ENGINEERING PARTS
ERR913 - T Seal - TURNER ENGINEERING PARTS
ERR1440 - Flywheel to Block - TURNER ENGINEERING PARTS
BTR982 - Heater Hose - TURNER ENGINEERING PARTS
Installed in 2019:
thicker eBay intercooler
Donaldson M002118 air filter clamps
Donaldson 546743 air filter
Stanadyne FM100 Fuel Filter setup
Revotec Electric Fan kit - Jan 2019
Valve cover gasket - March 2019
-6 AN Lines and fittings to IP
Approximately - 3,000 miles since 200tdi install
R380 Shorty
Serial: 55A60623008J
Purchased Sept 2014 from David Dearborn/Urban Land Cruisers
But didn't start using until 2016 after I finished the build of the 110. It was first behind an OM617
Approximately 5,000 miles on gearbox
Redlne fluid
$4,000